国际口腔医学杂志 ›› 2013, Vol. 40 ›› Issue (4): 440-443.doi: 10.7518/gjkq.2013.04.006

• 论著 • 上一篇    下一篇

不同浓度硅酸钠溶液液相沉积处理对钛瓷结合强度的影响

高宇1 吴占敖1 冯卫忠1 丁妍1 张德云2 姜涛1   

  1. 1.解放军第359医院口腔科 镇江 212001;2.解放军第452医院医务处 成都 610021
  • 收稿日期:2012-12-12 修回日期:2013-03-14 出版日期:2013-07-01 发布日期:2013-07-01
  • 通讯作者: 姜涛, Tel: 13852947711
  • 作者简介:高宇(1977—), 女, 黑龙江人, 主治医师, 学士
  • 基金资助:

    南京军区医学科技创新课题基金资助项目(10MA048)

Effect of silicate solution in different concentrations on bonding strength of porcelain and pure titanium by liquid-phase deposition technology

Gao Yu1, Wu Zhan’ao1, Feng Weizhong1, Ding Yan1, Zhang Deyun2, Jiang Tao1.   

  1. 1. Dept. of Stomatology, The 359 Hospital of PLA, Zhenjiang 212001, China; 2. Medical Department, The 452 Hospital of PLA, Chengdu 610021, China
  • Received:2012-12-12 Revised:2013-03-14 Online:2013-07-01 Published:2013-07-01

摘要:

目的 研究不同浓度Na2SiO3溶液的液相沉积处理对钛瓷结合强度的影响。方法 将40个纯钛试件平均分为4组, 喷砂后分别用3种浓度的Na2SiO3溶液对实验组试件进行液相沉积处理, 对照组不进行处理。检测各组试件粗糙度, 并用扫描电子显微镜观测表面形貌; 在试件中份烧结瓷粉后, 测各组试件钛瓷间的三点弯曲结合强度, 并对钛瓷结合界面进行扫描电子显微镜观察。结果 各组试件钛瓷结合界面均未见明显氧化层; 各实验组钛瓷结合强度均高于对照组; 0.3 mol·L-1组钛瓷结合强度最高。结论 通过液相沉积法在纯钛表面制备钛瓷界面中间层可提高钛瓷结合强度。

关键词: 纯钛, 钛瓷, 结合强度, 液相沉积, 中间层

Abstract:

Objective To study the effect of silicate solution in different concentrations on bonding strength of titanium and porcelain by liquid -phase deposition(LPD) technology. Methods Forty pure titanium specimens were randomly divided into four groups according to different surface treatments after sandblasting, and measured the roughness of each group. After the middle area of the samples was veneered with porcelain, a three-point-flexure-test was used to evaluate the bonding strength of titanium to porcelain. The interface of titanium and porcelain was investigated by scanning electron microscope(SEM). Results No definite oxide layer was observed at the interfaces in four groups. The bonding strength of groups of liquid-phase deposition were significantly higher than control group. The mean bonding strength of 0.3 mol·L-1 silicate solution group was the highest. Conclusion Middle layer prepared by LPD technology is significant in improving bonding strength of porcelain and pure titanium.

Key words: liquid-phase deposition, middle layer, pure titanium, titanium porcelain, bond strength

[1] 原小慧,刘杰. 微弧氧化技术提高钛-瓷结合强度的研究进展[J]. 国际口腔医学杂志, 2016, 43(6): 695-699.
[2] 孙旭1 翟浚江2 廖健2 滕敏华2 黄河1 郭长军1. 热盐酸结合加热处理对钛瓷结合强度的影响[J]. 国际口腔医学杂志, 2014, 41(5): 518-520.
[3] 董海涛 1 综述任卫红 2 审校. 控制钛的氧化行为对钛-瓷结合力的影响[J]. 国际口腔医学杂志, 2013, 40(2): 261-264.
[4] 岳虹池 高姗姗 李悦 于海洋. 注氮改性纯钛表面的微观摩擦性能研究[J]. 国际口腔医学杂志, 2012, 39(3): 317-320.
[5] 司家文1 万浩元1 胡启凡2 孙惠强1. 纯钛表面氧化钛和氧化锆涂层的结构性能及细胞毒性[J]. 国际口腔医学杂志, 2011, 38(5): 531-534.
[6] 邬烈,骆小平,舒成军,. 不同厚度纯钛基底冠适合性的比较研究[J]. 国际口腔医学杂志, 2007, 34(05): 328-330.
[7] 廖娟,徐薇,莫安春,. 纯钛种植体表面抗菌改性的研究进展[J]. 国际口腔医学杂志, 2007, 34(03): 213-215.
[8] 梁锐英,李长义,张连云,. 齿科用钛合金的研究进展[J]. 国际口腔医学杂志, 2006, 33(01): 45-47.
[9] 李哲 肖茂春. 铸造纯钛抛光方法的研究进展[J]. 国际口腔医学杂志, 2004, 31(03): 218-219.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] 王昆润. 修补颌骨缺损的新型生物学相容材料[J]. 国际口腔医学杂志, 1999, 26(06): .
[2] 陆加梅. 不可复性关节盘移位患者术前张口度与关节镜术后疗效的相关性[J]. 国际口腔医学杂志, 1999, 26(06): .
[3] 王昆润. 咀嚼口香糖对牙周组织微循环的影响[J]. 国际口腔医学杂志, 1999, 26(06): .
[4] 宋红. 青少年牙周炎外周血分叶核粒细胞的趋化功能[J]. 国际口腔医学杂志, 1999, 26(06): .
[5] 高卫民,李幸红. 发达国家牙医学院口腔种植学教学现状[J]. 国际口腔医学杂志, 1999, 26(06): .
[6] 侯锐. 正畸患者釉白斑损害的纵向激光荧光研究[J]. 国际口腔医学杂志, 1999, 26(05): .
[7] 轩东英. 不同赋形剂对氢氧化钙抗菌效果的影响[J]. 国际口腔医学杂志, 1999, 26(05): .
[8] 房兵. 唇腭裂新生儿前颌骨矫正方法及对上颌骨生长发育的影响[J]. 国际口腔医学杂志, 1999, 26(05): .
[9] 杨美祥. 前牙厚度在预测上下颌牙量协调性中的作用[J]. 国际口腔医学杂志, 1999, 26(04): .
[10] 赵艳丽. 手术刀、电凝、CO_2和KTP激光对大鼠舌部创口的作用[J]. 国际口腔医学杂志, 1999, 26(04): .